Search by Title only
Home > Maintenance > Scheduled maintenance service > Scheduled maintenance service precaution

Scheduled maintenance service precaution

Follow the Normal Maintenance Schedule if the vehicle is usually operated where none of the following conditions apply. If any of the following conditions apply, follow the Maintenance Under Severe Usage Conditions.

  • Repeated driving short distance of less than 8 km (5 miles) in normal temperature or less than 16 km (10 miles) in freezing temperature

  • Extensive engine idling or low speed driving for long distances

  • Driving on rough, dusty, muddy, unpaved, graveled or salt-spread roads

  • Driving in areas using salt or other corrosive materials or in very cold weather

  • Driving in heavy dust condition

  • Driving in heavy traffic area

  • Driving on uphill, downhill, or mountain road repeatedly

  • Using for towing or camping and driving with loading on the roof

  • Driving as a patrol car, taxi, other commercial use of vehicle towing

  • Frequently driving under high speed or rapid acceleration/deceleration.

  • Frequently driving in stop-and-go condition

If your vehicle is operated in any of the prior listed conditions, you should inspect, replace or refill more frequently, using the severe usage maintenance schedule instead of the normal usage maintenance schedule.

NOTICE

The vehicle may be equipped with the Oil Life Management System that predicts engine oil life based on the driver's driving history and alerts the driver to change engine oil.

  • If the deterioration of the engine oil increases depending on the driver's driving severity, the remaining oil life alert appears on the instrument cluster before the normal engine oil replacement interval. Have the engine oil and filter be changed by an authorized Kia dealer.

  • Oil Life Management System works when the recommended engine oil is used. So, if recommended engine oil is not used, replace the engine oil according to the maintenance schedule under severe usage condition. Also, check the amount of engine oil regularly as this system assumes that the engine oil is being filled normally.

  • Always reset the remaining engine oil life whenever the engine oil is changed. Otherwise, the Oil Life Management System will not be correct.

  • If there is no alert until the maximum maintenance interval, have vehicle be checked by an authorized Kia dealer.

Normal maintenance schedule

The following maintenance services must be performed to ensure good emission control and performance. Keep receipts for all vehicle services to protect your warranty. Where both mileage and date are shown, the frequency of service is determined by whichever occurs first.

I: Inspect and adjust, correct, clean, or replace if necessary.

R: Replace or change.

Number of months or driving distance, whichever comes first

Months

12

24

36

48

60

72

84

96

108

120

132

144

Miles x 1,000

8

16

24

32

40

48

56

64

72

80

88

96

Km x 1,000

13

26

39

52

65

78

91

104

117

130

143

156

Tire rotation

Rotate every 13,000 km (8,000 miles) or 12 months

Fuel additives*1

Add every 13,000 km (8,000 miles) or 12 months

Engine oil and engine oil filter*2

Smartstream G1.6 GDi HEV/PHEV

R

R

R

R

R

R

R

R

R

R

R

R

Climate control air filter

I

R

I

R

I

R

I

R

I

R

I

R

Air cleaner filter (Engine)

I

I

R

I

I

R

I

I

R

I

I

R

Brake fluid

Inspect every 13,000 km (8,000 miles) or 12 months

Replace every 78,000 km (48,000 miles) or 48 months

Spark plugs

Smartstream G1.6 GDi HEV/PHEV

Replace every 156,000 km (96,000 miles)

Coolant (Engine) *3

At first, replace at 195,000 km (120,000 miles) or 120 months

After that, replace every 39,000 km (24,000 miles) or 24 months

Coolant (Inverter)

HEV*4

At first, replace at 39,000 km (39,000 km) or 120 months

After that, replace every 39,000 km (24,000 miles) or 24 months

PHEV*5

Replace every 52,000 km (32,000 miles) or 36 months

Air conditioner refrigerant

I

I

I

I

I

I

I

I

I

I

I

I

Air conditioner compressor

12V Battery condition

PHEV

Brake discs and pads

Brake lines, hoses and connections

Suspension ball joints

Steering gear rack, linkage and boots

Exhaust system

Cooling system

Engine clutch actuator hose and line

Drive shaft and boots

-

I

-

I

-

I

-

I

-

I

-

I

Fuel tank and fuel cap

Fuel tank air filter

Fuel lines, hoses and connections

HSG (Hybrid Starter & Generator) belt*6

Inspect every 13,000 km (8,000 miles) or 12 months

Replace every 104,000 km (64,000 miles) or 48 months

Dual clutch transmission (DCT) fluid*

No service required

Engine clutch actuator fluid

Replace every 39,000 km (24,000 miles) or 24 months

*1. Fuel additives

If TOP TIER Detergent Gasoline is not available, one bottle of additive is recommended. Additives are available from your authorized Kia dealer along with information on how to use them. Do not mix other additives.

*2. Engine oil and engine oil filter

As it is normal for engine oil to be consumed during driving, the engine oil level should be checked on regular basis.

The engine oil change interval for normal operating conditions is based on the use of the recommended engine specification. If the recommended engine oil specification is not used, then replace the engine oil according to the maintenance schedule under severe operating conditions.

Never add additives to the engine oil. Engine oil additives can change its properties of engine oil and may cause serious engine failure.

*3. Coolant (Engine)

When adding coolant, use only deionized water or soft water for your vehicle and never mix hard water in the coolant filled at the factory. An improper coolant mixture can result in serious malfunction or engine damage.

*4. Coolant (HEV Inverter)

When adding coolant, use only deionized water or soft water for your vehicle and never mix hard water in the coolant filled at the factory. An improper coolant mixture can result in serious malfunction or engine damage.

*5. Coolant (PHEV Inverter)

Have the coolant replaced by an authorized Kia dealer.

*6.HSG (Hybrid Starter & Generator) belt

Inspect HSG belt for evidence of cuts, cracks, excessive wear or oil saturation and replace if necessary.

*Transmission fluid

If the vehicle has been submerged in water or in a flooded area, the fluids should be changed as a precaution.

Fuel filter (Gasoline engine)

The fuel filter is normally maintenance free but periodic inspection is recommended during scheduled maintenance to look for conditions caused by poor fuel quality.

  • If there are safety risks such as fuel flow restriction, surging, loss of power, hard starting problem etc, replace the fuel filter immediately regardless of maintenance schedule and consult an authorized Kia dealer for details.

Maintenance under severe usage conditions

I: Inspect and if necessary, adjust, correct, clean or replace.

R: Replace or change.

Maintenance item

Maintenance operation

Maintenance intervals

Driving condition

Engine oil and engine oil filter

R

Every 8,000 km (5,000 miles) or 6 months

D, H, I

HSG (Hybrid Starter & Generator) belt

R

Every 48,000 km (30,000 miles) or 24 months

B, C, D, E, I, K

I

Every 8,000 km (5,000 miles) or 6 months

Spark plugs

R

More frequently

A, B, F, G, H, I, K

Air cleaner filter

R

More frequently

C, E

Climate control air filter

R

More frequently

C, E, G

Dual clutch transmission (DCT) fluid

R

Every 117,000 km (72,000 miles)

C, D, F, G, H, I, J

Steering gear rack, linkage and boots

I

More frequently

C, D, E, F, G, H, I

Suspension ball joints

I

More frequently

C, D, E, G, H, I

Brake discs, pads and calipers

I

More frequently

C, D, E, G, H, I, J, K

Drive shaft and boots

I

More frequently

C, D, E, F, G, H, I, J

Severe driving conditions

A: Repeatedly driving short distance of less than 8 km (5 miles) in normal temperature or less than 16 km (10 miles) in freezing temperature.

B: Extensive engine idling or low speed driving for long distances.

C: Driving on rough, dusty, muddy, unpaved, graveled or saltspread roads.

D: Driving in areas using salt or other corrosive materials or in very cold weather

E: Driving in heavy dust condition.

F: Driving in heavy traffic area.

G: Driving on uphill, downhill, or mountain roads repeatedly.

H: Using for towing or camping and driving with loading on the roof

I: Driving for patrol car, taxi, other commercial use of vehicle towing.

J: Frequently driving under high speed or rapid acceleration/deceleration

K: Frequently driving in stop-and-go conditions.