Search by Title only
Home > Maintenance > Scheduled maintenance service > Scheduled maintenance service precaution

Scheduled maintenance service precaution

Follow the Normal Maintenance Schedule if the vehicle is usually operated where none of the following conditions apply. If any of the following conditions apply, follow the Maintenance Under Severe Usage Conditions.

  • Repeated driving short distance of less than 8 km (5 miles) in normal temperature or less than 16 km(10 miles) in freezing temperature

  • Extensive engine idling or low speed driving for long distances

  • Driving on rough, dusty, muddy, unpaved, gravelled or salt-spread roads

  • Driving in areas using salt or other corrosive materials or in very cold weather

  • Driving in heavy dust condition

  • Driving in heavy traffic area

  • Driving on uphill, downhill, or mountain road repeatedly

  • Towing a trailer or using a camper, or roof rack

  • Driving as a patrol car, taxi, other commercial use of vehicle towing

  • Driving over 170 km/h (106 mph)

  • Frequently driving in stop-and-go condition

  • Engine oil usage which not recommended (mineral, semi-synthetic, viscosity grade)

If your vehicle is operated under the above conditions, you should inspect, replace or refill more frequently than the following Normal Maintenance Schedule. After the periods or distance shown in the chart, continue to follow the prescribed maintenance intervals.

Normal maintenance schedule - for Australia and New Zealand

The following maintenance services must be performed to ensure good emission control and performance. Keep receipts for all vehicle emission services to protect your warranty. Where both mileage and time are shown, the frequency of service is determined by whichever occurs first.

NO.

ITEM

REMARK

* 1

Engine oil and engine oil filter

Check the engine oil level and leak every 500 km (350 miles) or before starting a long trip.

* 2

Engine oil and engine oil filter (For Diesel Engine, Europe)

  • If the recommended oil is not available, replace engine oil and engine oil filter every 30,000 km(20,000 miles) or 24 months.

  • The engine oil level should be checked regularly and maintained properly. Operating with an insufficient amount oil can damage the engine, and such damage is not covered by warranty.

  • This maintenance schedule depends on fuel quality. It is applicable only when using a qualified fuel <"EN590 or equivalent">. If the diesel fuel specifications don't meet the EN590, it must be replaced according to the severe maintenance schedule.

* 3

Coolant (Engine)

When adding coolant, use only deionized water or soft water for your vehicle and never mix hard water in the coolant filled at the factory. An improper coolant mixture can result in serious malfunction or engine damage.

* 4

Drive belts (Engine)

  • Adjust alternator, water pump and air conditioner drive belt. Inspect and if necessary repair or replace.

  • Inspect drive belt tensioner, idler and alternator pulley and if necessary correct or replace.

* 5

Spark plug

For your convenience, it can be replaced prior to it's interval when you do maintenance of other items.

* 6

Dual clutch transmission (DCT) fluid

Dual clutch transmission (DCT) fluid should be changed anytime it has been submerged in water.

* 7

Differential oil (rear)

Differential oil should be changed anytime it has been submerged in water.

* 8

Transfer case oil (AWD)

Transfer case oil should be changed anytime it has been submerged in water.

* 9

Fuel additives (Petrol)

Kia recommends that you use unleaded petrol which has an octane rating of RON (Research Octane Number) 95 / AKI (Anti Knock Index) 91 or higher (for Europe) or Octane Rating of RON (Research Octane Number) 91 / AKI (Anti-Knock Index) 87 or higher (except Europe).

For customers who do not use good quality petrol including fuel additives regularly, and have problems starting or the engine does not run smoothly, one bottle of additives should be added to the fuel tank at every 15,000 km (10,000 miles) (for Europe, Australia and New Zealand) / 10,000 km (6,500 miles) (except Europe, Australia and New Zealand, China, Brazil) / 5,000 km (3,000 miles) (for China, Brazil). Additives are available from a professional workshop along with information on how to use them. Kia recommends to visit an authorised Kia dealer/service partner. Do not mix other additives.

* 10

Fuel filter cartridge (Diesel)

If there are some important safety matters like fuel flow restriction, surging, loss of power, hard starting problem etc., replace the fuel filter immediately regardless of maintenance schedule. We recommend that you consult an authorised Kia dealer/service partner for details.

Normal maintenance schedule - Non Turbo Model [For Australia and New Zealand]

I: Inspect and if necessary, adjust, correct, clean or replace.

R: Replace or change.

MAINTENANCE INTERVALS /

MAINTENANCE ITEM

Number of months or driving distance, whichever comes first

Months

12

24

36

48

60

72

84

96

Miles×1,000

10

20

30

40

50

60

70

80

Km×1,000

15

30

45

60

75

90

105

120

Engine oil and engine oil filter *1

Replace every 15,000 km (10,000 miles) or 12 months

Coolant (Engine) *3

At first, Replace 210,000 km (140,000 miles) or 120 months after that, Replace every 30,000 km (20,000 miles) or 24 months

Drive belts (Engine) *4

-

I

-

I

-

I

-

I

Vacuum hoses and crankcase ventilation hoses

-

I

-

I

-

I

-

I

Spark plugs *5

Unleaded

Replace every 165,000 km (100,000 miles)

Leaded

Replace every 30,000 km (20,000 miles)

Automatic transmission fluid

No check, No service required

Dual clutch transmission (DCT) fluid *6

Inspect every 60,000 km (40,000 miles) or 48 months

Drive shaft and boots

-

I

-

I

-

I

-

I

Propeller shaft

-

I

-

I

-

I

-

I

Differential oil (rear) (AWD) *7

-

-

-

I

-

-

-

I

Transfer case oil (AWD) *8

-

-

-

I

-

-

-

I

Fuel additives (Petrol) *9

Add every 15,000 km (10,000 miles) or 12 months

Fuel filter (Petrol)

-

I

-

R

-

I

-

R

Fuel lines, hoses and connections

-

-

-

I

-

-

-

I

Fuel tank air filter (Petrol)

-

I

-

R

-

I

-

R

Vapour hose and fuel filler cap (Petrol)

-

-

-

I

-

-

-

I

Air cleaner filter

I

I

R

I

I

R

I

I

Exhaust system

-

I

-

I

-

I

-

I

Cooling system

-

-

-

I

-

I

-

I

Air conditioner compressor/refrigerant

I

I

I

I

I

I

I

I

Climate control air filter

I

R

I

R

I

R

I

R

Brake discs and pads

-

I

-

I

-

I

-

I

Brake lines, hoses and connections

-

I

-

I

-

I

-

I

Brake fluid

I

R

I

R

I

R

I

R

Parking brake (Foot type)

-

I

-

I

-

I

-

I

Steering gear rack, linkage and boots

I

I

I

I

I

I

I

I

Suspension ball joints

I

I

I

I

I

I

I

I

Tyre (pressure & tread wear)

I

I

I

I

I

I

I

I

Battery (12V) condition

-

I

-

I

-

I

-

I

  • Fuel filter: The fuel filter is considered to be maintenance free but periodic inspection is recommended for this maintenance schedule depends on fuel quality.

    • If there are some important safety matters like fuel flow restriction, surging, loss of power, hard starting problem etc, replace the fuel filter immediately regardless of maintenance schedule and consult an authorised KIA dealer for details.

Maintenance under severe usage conditions - Non Turbo Model [For Australia and New Zealand]

I: Inspect and if necessary, adjust, correct, clean or replace.

R: Replace or change.

MAINTENANCE ITEM

MAINTENANCE OPERATION

MAINTENANCE INTERVALS

DRIVING CONDITION

Engine oil and engine oil filter

R

Every 7,500 km (5,000 miles) or 6 months

A, B, C, D, E, F, G, H, I, J, K, L

Spark plugs

Unleaded

R

Replace every 165,000 km (100,000 miles)

A, B, F, G, H, I, K

Leaded

R

Replace every 30,000 km (20,000 miles)

A, B, F, G, H, I, K

Automatic transmission fluid

R

Every 90,000 km (60,000 miles)

A, C, D, E, F, G, H, I, J

Dual clutch transmission (DCT)

R

Every 100,000 km (62,000 miles)

A, C, D, E, F, G, H, I, J

Drive shaft and boots

I

Inspect more frequently depending on the condition

C, D, E, F, G, H, I, J

Propeller shaft

I

Inspect more frequently depending on the condition

C, D, E, F, G, H, I, J

Differential oil (rear) (AWD)

R

Every 120,000 km (80,000 miles)

C, E, G, H, I, J

Transfer case oil (AWD)

R

Every 120,000 km (80,000 miles)

C, E, G, H, I, J

Air cleaner filter

R

Replace more frequently depending on the condition

C, E

Climate control air filter

R

Replace more frequently depending on the condition

C, E, G

Brake discs and pads, calipers and rotors

I

Inspect more frequently depending on the condition

C, D, E, G, H

Parking brake (Foot Type)

I

Inspect more frequently depending on the condition

C, D, G, H

Steering gear rack, linkage and boots

I

Inspect more frequently depending on the condition

C, D, E, F, G

Suspension ball joints

I

Inspect more frequently depending on the condition

C, D, E, F, G

Severe driving conditions

A: Repeatedly driving short distance of less than 8 km (5 miles) in normal temperature or less than 16 km (10 miles) in freezing temperature.

B: Extensive engine idling or low speed driving for long distances.

C: Driving on rough, dusty, muddy, unpaved, gravelled or saltspread roads.

D: Driving in areas using salt or other corrosive materials or in very cold weather

E: Driving in heavy dust condition.

F: Driving in heavy traffic area.

G: Driving on uphill, downhill, or mountain roads repeatedly.

H: Towing a trailer or using a camper on roof rack.

I: Driving for patrol car, taxi, other commercial use of vehicle towing.

J: Driving over 170 km/h (106 mph).

K: Frequently driving in stop-and-go conditions.

L: Engine oil usage which not recommended (mineral, semi-synthetic, viscosity grade)

Normal maintenance schedule - Turbo Model [For Australia and New Zealand]

I: Inspect and if necessary, adjust, correct, clean or replace.

R: Replace or change.

MAINTENANCE INTERVALS /

MAINTENANCE ITEM

Number of months or driving distance, whichever comes first

Months

12

24

36

48

60

72

84

96

Miles×1,000

10

20

30

40

50

60

70

80

Km×1,000

15

30

45

60

75

90

105

120

Engine oil and engine oil filter *1

Diesel

Replace every 15,000 km (10,000 miles) or 12 months

Coolant (Engine) *3

Diesel

At first, Replace 210,000 km (140,000 miles) or 120 months after that, Replace every 30,000 km (20,000 miles) or 24 months

Drive belts (Engine) *4

Diesel

At first, Inspect 90,000 km(60,000 miles) or 48 months

After that, Inspect every 30,000 km(20,000 miles) or 24 months

Automatic transmission fluid

Diesel

No check, No service required

Dual clutch transmission(DCT) fluid *6

Diesel

Inspect every 60,000 km (40,000 miles) or 48 months

Drive shaft and boots

Diesel

-

I

-

I

-

I

-

I

Propeller shaft

Diesel

-

I

-

I

-

I

-

I

Differential oil (rear) (AWD) *7

Diesel

-

-

-

I

-

-

-

I

Transfer case oil (AWD) *8

Diesel

-

-

-

I

-

-

-

I

Fuel lines, hoses and connections

Diesel

-

I

-

I

-

I

-

I

Fuel filler cap (Diesel)

Diesel

-

-

-

I

-

-

-

I

Fuel filter cartridge (Diesel) *10

Diesel

-

I

-

R

-

I

-

R

Air cleaner filter

Diesel

I

I

R

I

I

R

I

I

Exhaust system

Diesel

-

I

-

I

-

I

-

I

Cooling system

Diesel

-

-

-

I

-

I

-

I

Air conditioner compressor/refrigerant

Diesel

I

I

I

I

I

I

I

I

Climate control air filter

Diesel

I

R

I

R

I

R

I

R

Brake discs and pads

Diesel

-

I

-

I

-

I

-

I

Brake lines, hoses and connections

Diesel

-

I

-

I

-

I

-

I

Brake fluid

Diesel

I

R

I

R

I

R

I

R

Parking brake (Foot type)

Diesel

-

I

-

I

-

I

-

I

Steering gear rack, linkage and boots

Diesel

I

I

I

I

I

I

I

I

Suspension ball joints

Diesel

I

I

I

I

I

I

I

I

Tyre (pressure & tread wear)

Diesel

I

I

I

I

I

I

I

I

Battery (12V) condition

Diesel

-

I

-

I

-

I

-

I

Timing belt system (Timing belt, Water pump, Tensioner, Idler)

Diesel

Inspect Timing belt every 120,000km (80,000miles)

Replace Timing belt system (Timing belt, Water pump, Tensioner, Idler) every 240,000km (160,000miles)

  • Fuel filter: The fuel filter is considered to be maintenance free but periodic inspection is recommended for this maintenance schedule depends on fuel quality.

    • If there are some important safety matters like fuel flow restriction, surging, loss of power, hard starting problem etc, replace the fuel filter immediately regardless of maintenance schedule and consult an authorised KIA dealer for details.

Maintenance under severe usage conditions - Turbo Model [For Australia and New Zealand]

I: Inspect and if necessary, adjust, correct, clean or replace.

R: Replace or change.

MAINTENANCE ITEM

MAINTENANCE OPERATION

MAINTENANCE INTERVALS

DRIVING CONDITION

Engine oil and engine oil filter

R

Every 7,500 km (4,500 miles) or 6 months

A, B, C, D, E, F, G, H, I, J, K, L

Automatic transmission fluid

R

Every 90,000 km (60,000 miles)

A, C, D, E, F, G, H, I, J

Dual clutch transmission (DCT)

R

Every 100,000 km (62,000 miles)

A, C, D, E, F, G, H, I, J

Drive shaft and boots

I

Inspect more frequently depending on the condition

C, D, E, F, G, H, I, J

Propeller shaft

I

Inspect more frequently depending on the condition

C, D, E, F, G, H, I, J

Differential oil (rear) (AWD)

R

Every 120,000 km (80,000 miles)

C, E, G, H, I, J

Transfer case oil (AWD)

R

Every 120,000 km (80,000 miles)

C, E, G, H, I, J

Air cleaner filter

R

Replace more frequently depending on the condition

C, E

Climate control air filter

R

Replace more frequently depending on the condition

C, E, G

Brake discs and pads, calipers and rotors

I

Inspect more frequently depending on the condition

C, D, E, G, H

Parking brake (Foot Type)

I

Inspect more frequently depending on the condition

C, D, G, H

Steering gear rack, linkage and boots

I

Inspect more frequently depending on the condition

C, D, E, F, G

Suspension ball joints

I

Inspect more frequently depending on the condition

C, D, E, F, G

Severe driving conditions

A: Repeatedly driving short distance of less than 8 km (5 miles) in normal temperature or less than 16 km (10 miles) in freezing temperature.

B: Extensive engine idling or low speed driving for long distances.

C: Driving on rough, dusty, muddy, unpaved, gravelled or saltspread roads.

D: Driving in areas using salt or other corrosive materials or in very cold weather

E: Driving in heavy dust condition.

F: Driving in heavy traffic area.

G: Driving on uphill, downhill, or mountain roads repeatedly.

H: Towing a trailer or using a camper on roof rack.

I: Driving for patrol car, taxi, other commercial use of vehicle towing.

J: Driving over 170 km/h (106 mph).

K: Frequently driving in stop-and-go conditions.

L: Engine oil usage which not recommended (mineral, semi-synthetic, viscosity grade)

Normal maintenance schedule - for Europe (Except Russia)

The following maintenance services must be performed to ensure good emission control and performance. Keep receipts for all vehicle emission services to protect your warranty. Where both mileage and time are shown, the frequency of service is determined by whichever occurs first.

NO.

ITEM

REMARK

* 1

Engine oil and engine oil filter

Check the engine oil level and leak every 500 km (350 miles) or before starting a long trip.

* 2

Engine oil and engine oil filter (For Diesel Engine, Europe)

  • If the recommended oil is not available, replace engine oil and engine oil filter every 30,000 km(20,000 miles) or 24 months.

  • The engine oil level should be checked regularly and maintained properly. Operating with an insufficient amount oil can damage the engine, and such damage is not covered by warranty.

  • This maintenance schedule depends on fuel quality. It is applicable only when using a qualified fuel <"EN590 or equivalent">. If the diesel fuel specifications don't meet the EN590, it must be replaced according to the severe maintenance schedule.

* 3

Coolant (Engine)

When adding coolant, use only deionized water or soft water for your vehicle and never mix hard water in the coolant filled at the factory. An improper coolant mixture can result in serious malfunction or engine damage.

* 4

Drive belts (Engine)

  • Adjust alternator, water pump and air conditioner drive belt. Inspect and if necessary repair or replace.

  • Inspect drive belt tensioner, idler and alternator pulley and if necessary correct or replace.

* 5

Spark plug

For your convenience, it can be replaced prior to it's interval when you do maintenance of other items.

* 6

Dual clutch transmission (DCT) fluid

Dual clutch transmission (DCT) fluid should be changed anytime it has been submerged in water.

* 7

Differential oil (rear)

Differential oil should be changed anytime it has been submerged in water.

* 8

Transfer case oil (AWD)

Transfer case oil should be changed anytime it has been submerged in water.

* 9

Fuel additives (Petrol)

Kia recommends that you use unleaded petrol which has an octane rating of RON (Research Octane Number) 95 / AKI (Anti Knock Index) 91 or higher (for Europe) or Octane Rating of RON (Research Octane Number) 91 / AKI (Anti-Knock Index) 87 or higher (except Europe).

For customers who do not use good quality petrol including fuel additives regularly, and have problems starting or the engine does not run smoothly, one bottle of additives should be added to the fuel tank at every 15,000 km (10,000 miles) (for Europe, Australia and New Zealand) / 10,000 km (6,500 miles) (except Europe, Australia and New Zealand, China, Brazil) / 5,000 km (3,000 miles) (for China, Brazil). Additives are available from a professional workshop along with information on how to use them. Kia recommends to visit an authorised Kia dealer/service partner. Do not mix other additives.

* 10

Fuel filter cartridge (Diesel)

If there are some important safety matters like fuel flow restriction, surging, loss of power, hard starting problem etc., replace the fuel filter immediately regardless of maintenance schedule. We recommend that you consult an authorised Kia dealer/service partner for details.

I: Inspect and if necessary, adjust, correct, clean or replace.

R: Replace or change.

MAINTENANCE INTERVALS /

MAINTENANCE ITEM

Normal Maintenance Schedule - For Europe (Except Russia)

Number of months or driving distance, whichever comes first

Months

24

48

72

96

120

144

168

192

Miles×1,000

20

40

60

80

100

120

140

160

Km×1,000

30

60

90

120

150

180

210

240

Engine oil and engine oil filter *1, *2

Petrol

Smartstream G2.5 MPI

Replace every 15,000 km (10,000 miles) or 12 months

Smartstream G3.5

Replace every 15,000 km (10,000 miles) or 12 months

Diesel

Smartstream D2.2

Replace every 30,000 km (20,000 miles) or 24 months

Coolant (Engine) *3

Petrol, Diesel

At first, Replace 210,000 km (140,000 miles) or 120 months

After that, Replace every 30,000 km (20,000 miles) or 24 months

Drive belts (Engine) *4

Petrol

Smartstream G2.5 MPI

At first, Inspect 90,000 km(60,000 miles) or 72 months

After that, Inspect every 30,000 km(20,000 miles) or 24 months

Smartstream G3.5

Diesel

Smartstream D2.2

At first, Inspect 90,000 km(60,000 miles) or 48 months

After that, Inspect every 30,000 km(20,000 miles) or 24 months

Vacuum hoses and crankcase ventilation hoses

Petrol

I

I

I

I

I

I

I

I

Spark plugs *5

Petrol

Smartstream G2.5 MPI

Unleaded

Replace every 165,000 km (100,000 miles)

Leaded

Replace every 30,000 km (20,000 miles)

Smartstream G3.5

Unleaded

Replace every 165,000 km (100,000 miles)

Leaded

Replace every 30,000 km (20,000 miles)

Automatic transmission fluid

Petrol, Diesel

No check, No service required

Dual clutch transmission (DCT) fluid *6

Petrol, Diesel

Inspect every 60,000 km (40,000 miles) or 48 months

Drive shaft and boots

Petrol, Diesel

I

I

I

I

I

I

I

I

Propeller shaft

Petrol, Diesel

I

I

I

I

I

I

I

I

Differential oil (rear) (AWD) *7

Petrol, Diesel

-

I

-

I

-

I

-

I

Transfer case oil (AWD) *8

Petrol, Diesel

-

I

-

I

-

I

-

I

Fuel additives (Petrol) *9

Petrol

Add every 15,000 km (10,000 miles) or 12 months

Fuel lines, hoses and connections

Petrol

-

I

-

I

-

I

-

I

Diesel

I

I

I

I

I

I

I

I

Fuel tank air filter (Petrol)

Petrol

-

I

-

I

-

I

-

I

Vapour hose and fuel filler cap (Petrol)

Petrol

-

I

-

I

-

I

-

I

Fuel filler cap (Diesel)

Diesel

-

I

-

I

-

I

-

I

Fuel filter cartridge (Diesel) *10

Diesel

I

R

I

R

I

R

I

R

Air cleaner filter

Petrol, Diesel

I

R

I

R

I

R

I

R

Exhaust system

Petrol, Diesel

I

I

I

I

I

I

I

I

Cooling system

Petrol, Diesel

-

I

I

I

I

I

I

I

Air conditioner compressor/refrigerant

Petrol, Diesel

I

I

I

I

I

I

I

I

Climate control air filter

Petrol, Diesel

R

R

R

R

R

R

R

R

Brake discs and pads

Petrol, Diesel

I

I

I

I

I

I

I

I

Brake lines, hoses and connections

Petrol, Diesel

I

I

I

I

I

I

I

I

Brake fluid

Petrol, Diesel

Inspect every 15,000 km(10,000 miles) or 12 months, Replace every 30,000 km(20,000 miles) or 24 months

Parking brake (Foot/Hand type)

Petrol, Diesel

I

I

I

I

I

I

I

I

Steering gear rack, linkage and boots

Petrol, Diesel

I

I

I

I

I

I

I

I

Suspension ball joints

Petrol, Diesel

I

I

I

I

I

I

I

I

Tyre (pressure & tread wear)

Petrol, Diesel

I

I

I

I

I

I

I

I

Battery (12V) condition

Petrol, Diesel

I

I

I

I

I

I

I

I

Urea solution line & connections (if equipped)

Diesel

I

I

I

I

I

I

I

I

Urea solution filler cap (if equipped)

Diesel

-

I

-

I

-

I

-

I

Timing belt system(Timing belt, Water pump, Tensioner, Idler)

Diesel

Inspect Timing belt every 120,000km (80,000miles

Replace Timing belt system (Timing belt, Water pump, Tensioner, Idler) every 240,000km (160,000miles)

Pan-European eCall system battery (if equipped)

Replace every 3 years.

  • Fuel filter (petrol engine) : The fuel filter is considered to be maintenance free but periodic inspection is recommended for this maintenance schedule depends on fuel quality.

    • If there are some important safety matters like fuel flow restriction, surging, loss of power, hard starting problem etc, replace the fuel filter immediately regardless of maintenance schedule and consult an authorised KIA dealer for details.

Maintenance under severe usage conditions - for Europe (Except Russia)

I: Inspect and if necessary, adjust, correct, clean or replace.

R: Replace or change.

MAINTENANCE ITEM

MAINTENANCE OPERATION

MAINTENANCE INTERVALS

DRIVING CONDITION

Engine oil and engine oil filter

Petrol

SmartStream G2.5 MPI

R

Replace every 7,500km (5,000 miles) or 6 months

A, B, C, D, E, F, G, H, I, J, K, L

Smartstream G3.5

R

Replace every 7,500km (5,000 miles) or 6 months

A, B, C, D, E, F, G, H, I, J, K, L

Diesel

Smartstream

D2.2

R

Replace every 15,000 km (10,000 miles) or 12 months

A, B, C, D, E, F, G, H, I, J, K, L

Spark plugs

Petrol

Smartstream G2.5 MPI

Unleaded

R

Replace every 165,000 km (100,000 miles)

A, B, F, G, H, I, K

Leaded

R

Replace every 30,000 km (20,000 miles)

A, B, F, G, H, I, K

Smartstream G3.5

Unleaded

R

Replace every 165,000 km (100,000 miles)

A, B, F, G, H, I, K

Leaded

R

Replace every 30,000 km (20,000 miles)

A, B, F, G, H, I, K

Automatic transmission fluid

Petrol, Diesel

R

Replace every 90,000 km (60,000 miles)

A, C, D, E, F, G, H, I, J

Dual clutch transmission (DCT) fluid

Petrol, Diesel

R

Replace every 100,000 km (62,000 miles)

A, C, D, E, F, G, H, I, J

Drive shaft and boots

Petrol, Diesel

I

Inspect more frequently depending on the condition

C, D, E, F, G, H, I, J

Propeller shaft

Petrol, Diesel

I

Inspect more frequently depending on the condition

C, D, E, F, G, H, I, J

Differential oil (rear) (AWD)

Petrol, Diesel

R

Replace every 120,000 km (80,000 miles)

C, E, G, H, I, J

Transfer case oil (AWD)

Petrol, Diesel

R

Replace every 120,000 km (80,000 miles)

C, E, G, H, I, J

Air cleaner filter

Petrol, Diesel

R

Replace more frequently depending on the condition

C, E

Climate control air filter

Petrol, Diesel

R

Replace more frequently depending on the condition

C, E, G

Brake discs and pads, calipers and rotors

Petrol, Diesel

I

Inspect more frequently depending on the condition

C, D, E, G, H

Parking brake

(Foot type)

Petrol, Diesel

I

Inspect more frequently depending on the condition

C, D, G, H

Steering gear rack, linkage and boots

Petrol, Diesel

I

Inspect more frequently depending on the condition

C, D, E, F, G

Severe driving conditions

A: Repeatedly driving short distance of less than 8 km (5 miles) in normal temperature or less than 16 km (10 miles) in freezing temperature.

B: Extensive engine idling or low speed driving for long distances.

C: Driving on rough, dusty, muddy, unpaved, gravelled or saltspread roads.

D: Driving in areas using salt or other corrosive materials or in very cold weather

E: Driving in heavy dust condition.

F: Driving in heavy traffic area.

G: Driving on uphill, downhill, or mountain roads repeatedly.

H: Towing a trailer or using a camper on roof rack.

I: Driving for patrol car, taxi, other commercial use of vehicle towing.

J: Driving over 170 km/h (106 mph).

K: Frequently driving in stop-and-go conditions.

L: Engine oil usage which not recommended (mineral, semi-synthetic, viscosity grade)

Normal maintenance schedule - except Europe (Including Russia)

The following maintenance services must be performed to ensure good emission control and performance. Keep receipts for all vehicle emission services to protect your warranty. Where both mileage and time are shown, the frequency of service is determined by whichever occurs first.

NO.

ITEM

REMARK

* 1

Engine oil and engine oil filter

Check the engine oil level and leak every 500 km (350 miles) or before starting a long trip.

* 2

Engine oil and engine oil filter (For Diesel Engine)

  • If the recommended oil is not available, replace engine oil and engine oil filter every 15,000 km(10,000 miles) or 12 months.

  • The engine oil level should be checked regularly and maintained properly. Operating with an insufficient amount oil can damage the engine, and such damage is not covered by warranty.

  • This maintenance schedule depends on fuel quality. It is applicable only when using a qualified fuel <"EN590 or equivalent">. If the diesel fuel specifications don't meet the EN590, it must be replaced according to the severe maintenance schedule.

* 3

Coolant (Engine)

When adding coolant, use only deionized water or soft water for your vehicle and never mix hard water in the coolant filled at the factory. An improper coolant mixture can result in serious malfunction or engine damage.

* 4

Drive belts (Engine)

  • Adjust alternator, water pump and air conditioner drive belt. Inspect and if necessary repair or replace.

  • Inspect drive belt tensioner, idler and alternator pulley and if necessary correct or replace.

* 5

Spark plug

For your convenience, it can be replaced prior to it's interval when you do maintenance of other items.

* 6

Dual clutch transmission (DCT) fluid

Dual clutch transmission (DCT) fluid should be changed anytime it has been submerged in water.

* 7

Differential oil (rear)

Differential oil should be changed anytime it has been submerged in water.

* 8

Transfer case oil (AWD)

Transfer case oil should be changed anytime it has been submerged in water.

* 9

Fuel additives (Petrol)

Kia recommends that you use unleaded petrol which has an octane rating of RON (Research Octane Number) 95 / AKI (Anti Knock Index) 91 or higher (for Europe) or Octane Rating of RON (Research Octane Number) 91 / AKI (Anti-Knock Index) 87 or higher (except Europe).

For customers who do not use good quality petrol including fuel additives regularly, and have problems starting or the engine does not run smoothly, one bottle of additives should be added to the fuel tank at every 15,000 km(10,000 miles) (for Europe, Australia and New Zealand) / 10,000 km(6,500 miles) (except Europe, Australia and New Zealand, China, Brazil)/ 5,000 km(3,000 miles) (for China, Brazil). Additives are available from a professional workshop along with information on how to use them. Kia recommends to visit an authorised Kia dealer/service partner. Do not mix other additives.

* 10

Fuel filter cartridge (Diesel)

If there are some important safety matters like fuel flow restriction, surging, loss of power, hard starting problem etc., replace the fuel filter immediately regardless of maintenance schedule. We recommend that you consult an authorised Kia dealer/service partner for details.

I: Inspect and if necessary, adjust, correct, clean or replace.

R: Replace or change.

MAINTENANCE INTERVALS /

MAINTENANCE ITEM

NORMAL MAINTENANCE SCHEDULE - EXCEPT EUROPE (INCLUDING RUSSIA)

Number of months or driving distance, whichever comes first

Months

12

24

36

48

60

72

84

96

Miles×1,000

10

20

30

40

50

60

70

80

Km×1,000

15

30

45

60

75

90

105

120

Engine oil and engine oil filter *1

Petrol

SmartStream G2.5 MPI

Except Middle East, Libya, Brazil, Central & South America, China

Replace every 15,000 km (10,000 miles) or 12 months

For Middle East, Libya, Brazil, Central & South America

Replace every 10,000 km (6,500 miles) or 12 months

For China

Replace every 5,000 km (3,000 miles) or 6 months

Smartstream G3.5

Except Middle East, Iran, India, Morocco, Algeria, Tunisia, Libya, Egypt, Sudan Central & South America, Brazil, China

Replace every 15,000 km (10,000 miles) or 12 months

For Middle East, Iran, India, Morocco, Algeria, Tunisia, Libya, Egypt, Sudan Central & South America, Brazil

Replace every 10,000 km (6,500 miles) or 12 months

For China

Replace every 5,000 km or 6 months

Diesel

Smartstream D2.2

For Russia and Republic of South Africa

Replace every 15,000 km (10,000 miles) or 12 months

Except Russia and Republic of South Africa

Replace every 10,000 km (6,500 miles) or 12 months

Coolant (Engine) *3

Petrol, Diesel

At first, Replace 210,000 km (140,000 miles) or 120 months after that, Replace every 30,000 km (20,000 miles) or 24 months

Drive belts (Engine) *4

Petrol

-

I

-

I

-

I

-

I

Diesel

For Russia and Republic of South Africa

At first, Inspect 90,000 km(60,000 miles) or 48 months

After that, Inspect every 30,000 km(20,000 miles) or 24 months

Except Russia and Republic of South Africa

At first, Inspect 80,000 km(50,000 miles) or 48 months

After that, Inspect every 20,000 km(12,500 miles) or 12 months

Vacuum hoses and crankcase ventilation hoses

Petrol

-

I

-

I

-

I

-

I

Spark plugs *5

Petrol

SmartStream G2.5 MPI

Unleaded

Replace every 165,000 km (100,000 miles)

Leaded

Replace every 30,000 km (20,000 miles)

Smartstream G3.5

Unleaded

Replace every 165,000 km (100,000 miles)

Leaded

Replace every 30,000 km (20,000 miles)

Automatic transmission fluid

Petrol, Diesel

No check, No service required

Dual clutch transmission(DCT) fluid *6

Petrol, Diesel

Inspect every 60,000 km (40,000 miles) or 48 months

Drive shaft and boots

Petrol, Diesel

-

I

-

I

-

I

-

I

Propeller shaft

Petrol, Diesel

-

I

-

I

-

I

-

I

Differential oil (rear) (AWD) *7

Petrol, Diesel

-

-

-

I

-

-

-

I

Transfer case oil (AWD) *8

Petrol, Diesel

-

-

-

I

-

-

-

I

Fuel additives (Petrol) *9

Petrol

Except China, Brazil

Add every 10,000 km (6,500 miles) or 6 months

For China, Brazil

Add every 5,000 km (3,000 miles) or 6 months

Fuel filter (Petrol)

Petrol

For China, Brazil

-

I

-

R

-

I

-

R

Fuel lines, hoses and con- nections

Petrol

-

-

-

I

-

-

-

I

Diesel

-

I

-

I

-

I

-

I

Fuel tank air filter (Petrol)

Petrol

Except China

-

I

-

R

-

I

-

R

For China

I

I

R

I

I

R

I

I

Vapour hose and fuel filler cap (Petrol)

Petrol

-

-

-

I

-

-

-

I

Fuel filler cap (Diesel)

Diesel

-

-

-

I

-

-

-

I

Fuel filter cartridge (Diesel) *10

Diesel

-

I

-

R

-

I

-

R

Air cleaner filter

Petrol, Diesel

Except China, India, Middle East

I

I

R

I

I

R

I

I

For China, India, Middle East

R

R

R

R

R

R

R

R

Exhaust system

Petrol, Diesel

-

I

-

I

-

I

-

I

Cooling system

Petrol, Diesel

-

-

-

I

-

I

-

I

Air conditioner compressor/refrigerant

Petrol, Diesel

I

I

I

I

I

I

I

I

Climate control air filter

Petrol, Diesel

R

R

R

R

R

R

R

R

Brake discs and pads

Petrol, Diesel

-

I

-

I

-

I

-

I

Brake lines, hoses and connections

Petrol, Diesel

-

I

-

I

-

I

-

I

Brake fluid

Petrol, Diesel

I

I

R

I

I

R

I

I

Parking brake (Foot type)

Petrol, Diesel

-

I

-

I

-

I

-

I

Steering gear rack, linkage and boots

Petrol, Diesel

I

I

I

I

I

I

I

I

Suspension ball joints

Petrol, Diesel

I

I

I

I

I

I

I

I

Tyre (pressure & tread wear)

Petrol, Diesel

I

I

I

I

I

I

I

I

Battery (12V) condition

Petrol, Diesel

Except Middle East

-

I

-

I

-

I

-

I

For Middle East

Inspect every 10,000 km (6,500 miles) or 6 months

Urea solution line & connections (if equipped)

Diesel

I

I

I

I

I

I

I

I

Urea solution filler cap (if equipped)

Diesel

-

-

-

I

-

-

-

I

Timing belt system (Timing belt, Water pump, Tensioner, Idler)

Diesel

Inspect Timing belt every 120,000km (80,000miles)

Replace Timing belt system (Timing belt, Water pump, Tensioner, Idler) every 240,000km (160,000miles)

  • Fuel filter: The fuel filter is considered to be maintenance free but periodic inspection is recommended for this maintenance schedule depends on fuel quality.

    • If there are some important safety matters like fuel flow restriction, surging, loss of power, hard starting problem etc, replace the fuel filter immediately regardless of maintenance schedule and consult an authorised KIA dealer for details.

Maintenance under severe usage conditions - except Europe (Including Russia)

I: Inspect and if necessary, adjust, correct, clean or replace.

R: Replace or change.

MAINTENANCE ITEM

MAINTENANCE OPERATION

MAINTENANCE INTERVALS

DRIVING CONDITION

Engine oil and engine oil filter

Petrol

SmartStream G2.5 MPI

Except Middle East, Libya, Brazil, Central & South America, China

R

Every 7,500 km (5,000 miles) or 6 months

A, B, C, D, E, F, G, H, I, J, K, L

For Middle East, Libya, Brazil, Central & South America

R

Every 5,000 km (3,000 miles) or 6 months

A, B, C, D, E, F, G, H, I, J, K, L

For China

R

Every 5,000 km (3,000 miles) or 3 months

A, B, C, D, E, F, G, H, I, J, K, L

Smartstream G3.5

Except Middle East, Iran, India, Morocco, Algeria, Tunisia, Libya, Egypt, Sudan, Central & South America, Brazil

R

Every 7,500 km (5,000 miles) or 6 months

A, B, C, D, E, F, G, H, I, J, K, L

For Middle East, Iran, India, Morocco, Algeria, Tunisia, Libya, Egypt, Sudan, Central & South America, Brazil

R

Every 5,000 km (3,000 miles) or 6 months

A, B, C, D, E, F, G, H, I, J, K, L

For China

R

Every 5,000 km (3,000 miles) or 6 months

A, B, C, D, E, F, G, H, I, J, K, L

Diesel

Smartstream D2.2

For Russia and Republic of South Africa

R

Every 7,500 km (4,500 miles) or 6 months

A, B, C, D, E, F, G, H, I, J, K, L

Except Russia and Republic of South Africa

R

Every 5,000 km (3,000 miles) or 6 months

A, B, C, D, E, F, G, H, I, J, K, L

Spark plugs

Petrol

Smartstream G2.5 MPI

Unleaded

R

Replace every 165,000 km (100,000 miles)

A, B, F, G, H, I, K

Leaded

R

Replace every 30,000 km (20,000 miles)

A, B, F, G, H, I, K

Smartstream G3.5

Unleaded

R

Replace every 165,000 km (100,000 miles)

A, B, F, G, H, I, K

Leaded

R

Replace every 30,000 km (20,000 miles)

A, B, F, G, H, I, K

Automatic transmission fluid

Petrol, Diesel

R

Every 90,000 km (60,000 miles)

A, C, D, E, F, G, H, I, J

Dual clutch transmission (DCT)

Petrol, Diesel

R

Every 100,000 km (62,000 miles)

A, C, D, E, F, G, H, I, J

Drive shaft and boots

Petrol, Diesel

I

Inspect more frequently depending on the condition

C, D, E, F, G, H, I, J

Propeller shaft

Petrol, Diesel

I

Inspect more frequently depending on the condition

C, D, E, F, G, H, I, J

Differential oil (rear) (AWD)

Petrol, Diesel

R

Every 120,000 km (80,000 miles)

C, E, G, H, I, J

Transfer case oil (AWD)

Petrol, Diesel

R

Every 120,000 km (80,000 miles)

C, E, G, H, I, J

Air cleaner filter

Petrol, Diesel

R

Replace more frequently depending on the condition

C, E

Climate control air filter

Petrol, Diesel

R

Replace more frequently depending on the condition

C, E, G

Brake discs and pads, calipers and rotors

Petrol, Diesel

I

Inspect more frequently depending on the condition

C, D, E, G, H

Parking brake (Foot Type)

Petrol, Diesel

I

Inspect more frequently depending on the condition

C, D, G, H

Steering gear rack, linkage and boots

Petrol, Diesel

I

Inspect more frequently depending on the condition

C, D, E, F, G

Suspension ball joints

Petrol, Diesel

I

Inspect more frequently depending on the condition

C, D, E, F, G

Severe driving conditions

A: Repeatedly driving short distance of less than 8 km (5 miles) in normal temperature or less than 16 km (10 miles) in freezing temperature.

B: Extensive engine idling or low speed driving for long distances.

C: Driving on rough, dusty, muddy, unpaved, gravelled or saltspread roads.

D: Driving in areas using salt or other corrosive materials or in very cold weather

E: Driving in heavy dust condition.

F: Driving in heavy traffic area.

G: Driving on uphill, downhill, or mountain roads repeatedly.

H: Towing a trailer or using a camper on roof rack.

I: Driving for patrol car, taxi, other commercial use of vehicle towing.

J: Driving over 170 km/h (106 mph).

K: Frequently driving in stop-and-go conditions.

L: Engine oil usage which not recommended (mineral, semi-synthetic, viscosity grade)